小型攪拌機安全的操作，是保證人身安全和機器設備使用壽命的必要前提！下面小編來講講小型攪拌機出料時須當心什么事。

Safe operation of small mixers is a necessary prerequisite to ensure personal safety and the service life of machinery and equipment! Let's talk about what to be careful about when discharging materials from small mixers.

1、卸料前讓攪拌機全速運轉幾分鐘

1. Allow the mixer to run at full speed for a few minutes before discharging

高速轉動讓混凝土充分攪拌，防止凝固，可以加一些水，方面出料?？哲囘\轉，檢查攪拌筒或攪拌葉的轉動方向，各工作裝置的操作、制動、確認正常，方可作業。

High speed rotation allows the concrete to be fully mixed to prevent solidification. Some water can be added for discharging. Operate without load, check the rotation direction of the mixing drum or mixing blade, and confirm that the operation, braking and operation of each working device are normal before operation.

2、出料前先把出料斗溜槽打濕

2. Wet the chute of discharge hopper before discharging

盡量將車停在平地上出料，出料前先把出料溜槽打濕，防止混凝土粘結在溜槽，容易清洗。

Try to park the vehicle on the flat ground for discharging. Before discharging, wet the discharge chute to prevent the concrete from sticking to the chute and easy to clean.

進料時，嚴禁將頭或手伸入料斗與機架之間，運轉中不得用手或工具等物伸入攪拌筒內扒料出料。

When feeding, it is strictly forbidden to put your head or hand between the hopper and the rack. During operation, it is not allowed to put your hand or tools into the mixing drum to remove the material.

料斗升起時，嚴禁在其下方工作或穿行。料坑底部要設料斗的枕墊，清理料坑時須將料斗用鏈條扣牢。

When the hopper is raised, it is strictly forbidden to work or walk under it. The pillow pad of the hopper shall be set at the bottom of the pit, and the hopper shall be fastened with a chain when cleaning the pit.

3、卸料不要大意

3. Don't be careless in discharging

出料時全程看著，免得放料工亂操作放料操作桿，每次罐子正反轉中間位子時好停一下，保護減速機，托盤。

When discharging, watch the whole process to prevent the discharging operator from operating the discharging lever randomly. Stop every time the can is in the middle of the positive and reverse direction to protect the reducer and tray.

4、攪拌機沖洗干凈

4. Rinse the mixer

作業后，應對攪拌機進行多方面清洗，操作人員如需進入筒內清洗時，須切斷電源，設專人在外監護，或卸下熔斷器并鎖好電閘箱，然后方可進入。

After the operation, the mixer shall be cleaned in many ways. If the operator needs to enter the cylinder for cleaning, he/she must cut off the power supply, assign a special person to monitor outside, or remove the fuse and lock the switch box before entering.

小型攪拌機作業中，如發生故障不能繼續運轉時，應立即切斷電源，將攪拌筒內的混凝土清除干凈。

During the operation of small mixer, if the mixer cannot continue to operate due to failure, the power supply shall be cut off immediately to remove the concrete in the mixing drum.

以上就是小編總結的小型攪拌機出料時須當心什么事的相關內容了，請大家在使用時遵循規章制度，安全生產。關注我們http://www.wanyituangou.com，了解更多事！

The above is the relevant content of what to be careful about when discharging the small mixer summarized by Xiao Bian. Please follow the rules and regulations when using it to ensure safe production. Follow us http://www.wanyituangou.com , learn more!